Any Road legal freestyle buggies for sale ?

Do you need anything?? just put it in here and we can help
250buggys
Posts: 818
Joined: Fri May 02, 2014 10:09 am
Location: Essex

Re: Any Road legal freestyle buggies for sale ?

Postby 250buggys » Mon Apr 05, 2021 9:13 am

I would not recommend running no antifreeze as it has corrosion inhibitors, will stop the water freezing in the winter which may result in a cracked block or popping the core plugs out.

I also wouldn't bother with the addition as this is just masking the problem, you just need to get to the route cause so your buggy is more reliable so you don't get caught out and have to call RAC.

Can you post a pic of the back end of buggy as may be able to see if there is anything blocking the very limited air flow the buggy gets.

Did you test with a sheet of A4 to make sure the mechanical and electric fans are pushing and pulling the air the correct way?

I have wired a dash switch as an override for the fan but not used it yet as the cooling system is pretty stable.

User avatar
Phaeton
Posts: 4817
Joined: Mon Jan 29, 2007 9:13 pm
Location: Worksop
Contact:

Re: Any Road legal freestyle buggies for sale ?

Postby Phaeton » Mon Apr 05, 2021 10:49 am

An overflow header tank may help, as a small amount being pushed out is quite normal, I used to run a heater matrix on the heater circuit in the airflow just to add a bit extra cooling, think I even fitted a fan to it. I did in the end go front mounted rad which solved all the cooling problems, but then effectively lowered the car, as I never went offroad apart from when Danny forced me off it never mattered. I always wanted to put them down the side of the passenger side & make a feature of them, but never got around to it.

250buggys
Posts: 818
Joined: Fri May 02, 2014 10:09 am
Location: Essex

Re: Any Road legal freestyle buggies for sale ?

Postby 250buggys » Mon Apr 05, 2021 10:59 am

like this one

Turbo.jpg

User avatar
Phaeton
Posts: 4817
Joined: Mon Jan 29, 2007 9:13 pm
Location: Worksop
Contact:

Re: Any Road legal freestyle buggies for sale ?

Postby Phaeton » Mon Apr 05, 2021 12:07 pm

Similar, my idea was to take both down the same side & then cover with a heat shield like you'd have on a Seven type exhaust, I'd just be concerned at kids grabbing hold of that pipe when just parked up, or catching your leg on it as you get out, no idea if you would but I know I took all the skin off my leg on the Robin Hood exhaust

User avatar
Danny
Posts: 4265
Joined: Wed Jan 17, 2007 9:23 pm
Location: Middleton On Sea
Contact:

Re: Any Road legal freestyle buggies for sale ?

Postby Danny » Mon Apr 05, 2021 3:10 pm

More water capacity is the key.

Or front rad

Sent from my SM-N950F using Tapatalk
Image

Leigh1299
Posts: 24
Joined: Sat Jul 25, 2020 7:12 pm

Re: Any Road legal freestyle buggies for sale ?

Postby Leigh1299 » Mon Apr 05, 2021 10:56 pm

After an afternoon of investigation, I think it’s just the radiator cap that’s allowing coolant to escape out through the centre of it . I put sealant over the centre and allowed to cure , went on a 5 mile trip came home and sat idling on the drive for 10 mins and only a small amount came out under the sealant. I’ve purchased the 15lb cap as I have the 13lb currently to see if this helps !
Thank you for all the help !


Return to “WANTED”

Who is online

Users browsing this forum: No registered users and 4 guests